Intel ISP1100 User Manual

Intel® ISP1100 Internet ServerProduct GuideA Guide for Technically Qualified Assemblers of Intel® Identified Subassemblies/ProductsOrder Number: A105

10 Intel ISP1100 Internet Server Product GuideControls, Connectors, and IndicatorsFront PanelFigure 3 shows the locations of the server front-panel co

Description 11ProcessorsThe server board supports a single Intel Pentium III processor or Celeron processor that plugs into aPGA370 socket connector t

12 Intel ISP1100 Internet Server Product Guide• Unbuffered DIMMs of the following sizes: 16 MB, 32 MB, 64 MB, 128 MB and 256 MB for atotal memory siz

Description 13NOTEAll memory components used with the server board should comply with thefollowing PC SDRAM specifications (see Chapter 13 in the Inte

14 Intel ISP1100 Internet Server Product GuideIDE SupportThe server board has two independent bus-mastering IDE interfaces that support:1. ATAPI devi

Description 15I/O ControllerThe FDC37B807 I/O controller from SMSC is an ISA Plug and Play-compatible, multifunctionalI/O device that provides the fol

16 Intel ISP1100 Internet Server Product GuideKeyboard and Mouse InterfaceThe PS/2 keyboard and mouse connectors are located on the server back panel.

Description 17For more details on programming and reading the Heceta 2 chip please refer to the Heceta 2 DeviceSpecification version 1.2 or later (see

18 Intel ISP1100 Internet Server Product GuideWake on Ring/Resume on RingWake on Ring enables the computer to wake from sleep or soft-off mode when a

Description 19SMI and NMI RoutingThere are numerous SMI sources and all are routed to the PIIX4. Software must configure thePIIX4 SMI source pins to

DisclaimerIntel Corporation (Intel) makes no warranty of any kind with regard to this material, including, but not limited to, the impliedwarranties o

20 Intel ISP1100 Internet Server Product GuideFan SupportThe server board has five fan connectors. The functions of the fan connectors are described

212 Removing/Installing Server ComponentsThis chapter provides procedures for removing and installing replaceable and/or upgradablecomponents in the I

22 Intel ISP1100 Internet Server Product GuideWARNINGSThis chapter is intended for qualified technical personnel withexperience installing and configu

Removing/Installing Server Components 23Rackmount PrecautionsFamiliarize yourself with the following precautions before rackmounting the server.WARNIN

24 Intel ISP1100 Internet Server Product GuideSafety and Regulatory RequirementsThis product was evaluated for use in computer racks within computer r

Removing/Installing Server Components 25Installing the Server in the RackThis procedure describes how to install the server in the rack. Before proce

26 Intel ISP1100 Internet Server Product GuideRemoving the CoverThis procedure describes how to remove the cover from the server. Before proceeding,

Removing/Installing Server Components 27Removing the ProcessorThis procedure describes how to remove the processor on the server board. Before procee

28 Intel ISP1100 Internet Server Product GuideRemoving the Processor ChipPerform this procedure to remove the processor chip from the socket. Refer t

Removing/Installing Server Components 29Removing the Processor Fan (If Applicable)This procedure describes how to remove the processor fan from a repl

iiiContents1 DescriptionSystem Components ...

30 Intel ISP1100 Internet Server Product GuideInstalling the Processor ChipPerform this procedure to install the processor chip in the socket. Refer

Removing/Installing Server Components 31Installing the Processor Heat SinkPerform this procedure to install the heat sink on the processor chip. Refe

32 Intel ISP1100 Internet Server Product GuideRemoving the DIMM BoardsThis procedure describes how to remove DIMM boards from the server board sockets

Removing/Installing Server Components 33Installing the DIMM BoardsThis procedure describes how to install DIMM boards on the server board. Before pro

34 Intel ISP1100 Internet Server Product GuideRemoving the Hard Drive(s)This procedure describes how to remove the hard drives from the server drive b

Removing/Installing Server Components 35Installing the Hard Drive(s)This procedure describes how to install hard drives in the server drive bays. Bef

36 Intel ISP1100 Internet Server Product GuideInstalling the Hard Drive in the Drive BayPerform this procedure to install the mounting bracket with th

Removing/Installing Server Components 37Removing the 3.5-inch Diskette DriveThis procedure describes how to remove the 3.5-inch diskette drive from th

38 Intel ISP1100 Internet Server Product GuideInstalling the 3.5-inch Diskette DriveThis procedure describes how to install the 3.5-inch diskette driv

Removing/Installing Server Components 39Installing the 3.5-inch Diskette Drive in the Drive BayPerform this procedure to install the mounting bracket

iv Intel ISP1100 Internet Server Product GuideInstalling the Processor ...

40 Intel ISP1100 Internet Server Product GuideRemoving the PCI Add-in Card(s)This procedure describes how to remove the PCI add-in card(s) from the se

Removing/Installing Server Components 41Removing the Riser and Add-in Card(s)Perform this procedure to remove the riser and add-in card(s) from the se

42 Intel ISP1100 Internet Server Product GuideRemoving the Add-in Card(s) From the RiserPerform this procedure to remove the add-in card(s) from the r

Removing/Installing Server Components 43Installing the Rear I/O Filler Panel(s)CAUTIONBe sure any empty expansion slot(s) have a filler panel installe

44 Intel ISP1100 Internet Server Product GuideInstalling PCI Add-in Card(s)This procedure describes how to install the PCI add-in card(s) in the serve

Removing/Installing Server Components 45

46 Intel ISP1100 Internet Server Product GuideInstalling the Add-in Card(s) on the RiserPerform this procedure to install the standard or low-profile

Removing/Installing Server Components 47Removing the Rear I/O Filler Panel(s) NOTEPerform this procedure only if you are installing PCI add-in card(s

48 Intel ISP1100 Internet Server Product GuideInstalling the Riser and Add-in Card(s)Perform this procedure to install the riser and add-in card(s) in

Removing/Installing Server Components 49Replacing the Back-up BatteryThis procedure describes how to remove and replace the lithium battery on the ser

Contents vAfter the System Has Been Running Correctly ... 69Checklist...

50 Intel ISP1100 Internet Server Product Guide1. Remove the server cover as described in the “Removing the Server Cover” procedure.2. Insert the tip

Removing/Installing Server Components 51Power Up the ServerThis procedure describes how to apply AC power and power up the server (refer to Figure 29)

52 Intel ISP1100 Internet Server Product Guide1. Attach the female end of the appropriate AC power cord to the mating AC power receptacle onthe serve

Removing/Installing Server Components 53

543 Configuration Software and UtilitiesThis chapter describes the Power-On Self-Test (POST) and server configuration utilities. The tablebelow brie

Configuration Software and Utilities 55Note the screen display and write down the beep code you hear; this information is useful for yourservice repre

56 Intel ISP1100 Internet Server Product GuideTable 11. BIOS Setup Function Keys (continued)Setup KeyDescription<↑> or <↓>Select Item: The

Configuration Software and Utilities 57Advanced MenuThe menu bar is shown below.MainAdvancedSecurity BootSystemManagementExitTable 13 shows the Advanc

58 Intel ISP1100 Internet Server Product GuideTable 16. IDE Configuration MenuFeature Options DescriptionIDEControllerBoot (default)DisabledPrimarySec

Configuration Software and Utilities 59Table 17. IDE Configuration Submenu (continued)Feature Options DescriptionPIO Mode Auto (default)01234Configure

vi Intel ISP1100 Internet Server Product Guide25. Installing the Add-in Card(s) on the Riser ...

60 Intel ISP1100 Internet Server Product GuideSecurity MenuThe menu bar is shown below.Main Advanced SecurityBootSystemManagementExitTable 20 shows th

Configuration Software and Utilities 61Table 21. Boot Menu (continued)Feature Options DescriptionAfter PowerFailureStays OffLast State (default)Power

62 Intel ISP1100 Internet Server Product GuideSystem Management MenuThe menu bar is shown below.Main Advanced Security BootSystemManagementExitTable 2

Configuration Software and Utilities 63Exit MenuThe menu bar is shown below.Main Advanced SecurityBootSystemManagementExitTable 23 shows the Exit menu

64 Intel ISP1100 Internet Server Product GuideObtaining the Upgrade UtilityYou can upgrade to a new version of the BIOS using the new BIOS files and t

Configuration Software and Utilities 657. To extract the BIOS.EXE file to the floppy disk, change to the temporary directory that holds theBIOS.EXE f

66 Intel ISP1100 Internet Server Product Guide8. Two beeps and the end of activity in drive A indicate successful BIOS recovery.9. A series of conti

Configuration Software and Utilities 67

684 Solving ProblemsThis chapter helps you identify and solve problems that might occur while you are using thesystem.Resetting the SystemTo do this:

Solving Problems 69Running New Application SoftwareProblems that occur when you run new application software are usually related to the software.Fault

71 DescriptionSystem ComponentsFigure 1 shows the location of the major system components in the Intel® ISP1100 Internet Server.BCMDAOMO9445EHLKNFGJIA

70 Intel ISP1100 Internet Server Product GuideMore Problem Solving ProceduresThis section provides a more detailed approach to identifying a problem a

Solving Problems 71Specific Problems and Corrective ActionsThis section provides possible solutions for these specific problems:• Power light does no

72 Intel ISP1100 Internet Server Product Guide4. If you do not receive a beep code and characters do not appear, the video display monitor orvideo co

Solving Problems 73Hard Disk Drive Activity Light Does Not LightIf you have installed one or more hard disk drives in your system, check the following

74 Intel ISP1100 Internet Server Product Guideq Check the network controller LEDs that are visible through an opening at the system backpanel.Problem

Solving Problems 75q If other software runs correctly on the system, contact your vendor about the failing software.If the problem persists, contact

76 Intel ISP1100 Internet Server Product GuideTable 25. Error Messages DescriptionError MessageDescription8042 Gate-A20 Error Gate A20 on the keyboard

Solving Problems 77Table 25. Error Messages Description (continued)Error MessageDescriptionNo ROM BASIC Cannot find a proper bootable sector on drive

78 Intel ISP1100 Internet Server Product GuideIndexAadd-in cardsinstallation, 44, 47installation on riser, 45removal, 40audible beep error codes, 53Bb

Index 79II/O controller, 15diskette drive controller, 15keyboard and mouse interface, 16serial ports, 15IDE support, 14indicators, 10K - Lkeyboard and

8 Intel ISP1100 Internet Server Product GuideServer Board FeaturesTable 1 summarizes the TR440BX server board features.Table 1. Server Board FeaturesF

80 Intel ISP1100 Internet Server Product Guideremoving/installing server components(continued)removing the PCI add-in cards, 40removing the processor,

Index 81

Description 9Server Board Connectors and ComponentsFigure 2 shows the locations of the server board connectors and components.AB CDEFGHJIKLMNOPQRSTUVW